BY ORDER OF THE COMMANDER 8TH FIGHTER WING 8TH FIGHTER WING INSTRUCTION 21-103 28 NOVEMBER 2012 Maintenance CRASH, DAMAGED OR DISABLED AIRCRAFT RECOVERY (CDDAR) PLAN COMPLIANCE WITH THIS PUBLICATION IS MANDATORY ACCESSIBILITY: Publications and forms are available on the e-publishing website at www.epublishing.af.mil for downloading or ordering RELEASABILITY: There are no releasability restrictions on this publication OPR: 8 MXS/MXMTT Supersedes: 8FWI21-103, 6 April 2010 Certified by: 8 MXG/CC (Colonel Ray A. Lindsay) Pages: 19 This instruction implements Air Force Policy Directive (AFPD) 21-1, Air and Space Maintenance. This instruction establishes guidance to effectively respond to and recover crashed, damaged and disabled aircraft during normal and major aircraft emergencies/mishaps on or off of the 8th Fighter Wing, Kunsan Air Base, Republic of Korea. It will be used in conjunction with AFI21-101_COMBAT AIR FORCE SUP, Aerospace Equipment Maintenance Management, AFI 10-2501, United States Air Force Emergency Management (EM) Program Planning and Operations, AFI 10-2502, Air Force Incident Management System (AFIMS) Standards and Procedures,, 8 FW Comprehensive Emergency Management Plan (8 FW CEMP 10-2); 8 FW Mishap Response Plan 91-204, LCL-8MXG-003, Emergency Action Checklist. This instruction applies to all base agencies assigned supporting emergency management duties under 8 FW CEMP 10-2 and T.O. 00-105E-9, Aircraft Emergency Rescue Information. Refer recommended changes and questions about this publication to the Office of Primary Responsibility (OPR) using the AF Form 847, Recommendation for Change of Publication; route the AF Forms 847 from the field through the appropriate functional chain of command. Ensure that all records created as a result of processes prescribed in this publication are maintained in accordance with Air Force Manual (AFMAN) 33-363, Management of Records, and disposed of in accordance with Air Force Records Information Management System (AFRIMS) Records Disposition Schedule (RDS) located at https://www.my.af.mil/afrims/afrims/afrims/rims.cfm. The use of the name or mark of any specific manufacturer, commercial product, commodity, or service in this publication does not imply endorsement by the Air Force. It applies to all personnel assigned, attached, or associated units to the 8th Fighter Wing (8 FW), Kunsan Air Base, Republic of Korea.
2 8FWI21-103 28 NOVEMBER 2012 SUMMARY OF CHANGES This document is substantially revised and must be completely reviewed. The Incident Commander definition and responsibilities have been expanded. Responsibilities of the MXS/MXMTT Section Chief have been redefined and expanded. Recover and Response Procedures have been updated, including Normal Response and Major Response. 1. General.... 2 2. Generalized CDDAR Responsibilities... 2 3. Definitions... 3 4. Responsibilities... 4 5. Crash Recovery Response Procedures.... 7 6. On/Off-Base Recovery Procedures.... 9 7. Additional Training and Certification Requirements for CRT Personnel.... 10 8. Supplemental Procedures.... 11 Attachment 1 GLOSSARY OF REFERENCES AND SUPPORTING INFORMATION 12 Attachment 2 GROUP LETTERHEAD STATIONARY SAMPLE MEMORANDUM 15 Attachment 3 GROUP LETTERHEAD STATIONARY SAMPLE MEMORANDUM 16 Attachment 4 SAMPLE MEMORANDUM FOR EQUIPMENT SHORTAGE NOTIFICATION 17 Attachment 5 SAMPLE MEMORANDUM RESPONSE EQUIPMENT LISTING 18 Attachment 6 SAMPLE MEMORANDUM VEHICLE REQUIREMENTS 19 1. General. The 8th Maintenance Squadron Commander (8 MXS/CC) has the primary responsibility for conducting CDDAR operations, as directed by the 8th Maintenance Group Commander (8 MXG/CC). The 8th Fighter Wing, Maintenance Operations Center (MOC) will implement the maintenance group commander s instructions and will request support from transient aircraft home station/majcom as required. Maintenance Flight will develop CDDAR procedures in coordination with the base 8th Civil Engineers Squadron/Fire Department (8 CES/CEF), 8th Fighter Wing/Ground Safety (8 FW/SEG), 8 CES/Readiness and Emergency Management Flight (8 CES/CEX), 8th Medical Operations Squadron/Base Bioenvironmental Engineering (8 MDOS/SGOJ), 8th Security Forces Squadron (8 SFS), 8 CES/Explosive Ordnance Disposal Flight (8 CES/CED), 8th Operations Support Squadron/Airfield Manager (8 OSS/OSAM) and other on/off base agencies as applicable. 2. Generalized CDDAR Responsibilities 2.1. Supervisors at all levels must recognize the sources of hazards and apply appropriate safety practices to minimize their effect. There is an infinite variety of possible emergency and crash recovery situations; therefore, specific procedures cannot be prescribed for every
8FWI21-103 28 NOVEMBER 2012 3 situation. All aircraft recovery actions are coordinated through the Incident Commander (IC) to the Emergency Operations Center (EOC). Practice and participation in wing crash recovery exercises and implementation of operational risk management techniques are imperative for all emergency and crash recovery operations. 3. Definitions 3.1. Normal Responses: Aircrew declared In-Flight Emergencies (IFE) and Ground Emergencies (GE) requiring crash recovery team responses but limited action in recovering the aircraft. Examples: Flight control malfunctions, radio failures, bird strikes, hydrazine leaks/spills, low fuel, hung ordnance and gun malfunctions, emergency power unit activations, hot brakes, blown tires, hung flares, barrier engagement/cable arrestment, etc. 3.2. Major Responses: Aircrew declared emergencies requiring crash recovery team response and action in recovering and removing an aircraft by means of lifting. Examples: Landing gear will not extend, collapsed landing gear, aircraft departs runway/taxiway and/or aircraft crashes, etc. 3.3. Incident Commander (IC): The Incident Commander (IC) is a trained and experienced responder who provides on-scene tactical control using subject matter experts (SME) and support from other functionals. Normally, ICs are SMEs from the Fire, Medical, or SF response elements. The IC will use the Air Force Incident Management System (AFIMS) to manage the incident. 3.3.1. Depending upon the situation, other personnel may function as ICs if they have completed Incident Command System (ICS) training IAW Chapter 6 and meet DOD and Federal certification standards for the specific type of incident. For example, the IC must meet Department of Defense Instruction (DODI) 6055.6, DOD Fire and Emergency Services Program and Department of Defense Manual (DODM) 6055.6, DOD Fire and Emergency Services Certification Program, requirements for Hazardous Materials (HAZMAT) and suspected Chemical, Biological, Radiological, Nuclear (CBRN) responses. Fire Emergency Services (FES) personnel serve as IC for EOD incidents during peacetime and terrorist response incidents after SF have contained or neutralized any hostile forces. 3.4. Senior Fire Official (SFO): Fire department personnel by certification and duty position assigned responsibility for all fire fighting and rescue actions. 3.5. Crash Recovery Team Chief (CRTC): Individual assigned responsibility for managing the crash recovery program according to Air Force instructions, wing mission plans, and applicable host-tenant agreements. Qualification will consist of reviewing the following: 8 FWI 21-103, Crash, Damaged or Disabled Aircraft Recovery Plan, AFI 21-101 COMBAT AIR FORCE SUP, 8 FW/ROKAF Base Support Agreement, 8 MOS/MTF Crash Recovery Lesson Plan, 8 FW OPLAN 31-1, 8 FW Full Spectrum Threat Response, 8 FWI 91-202, Mishap Prevention Program, and LCL-8FW-MS/TA-100, Crash Recovery Response Checklist. 3.6. Crash Recovery Team Supervisor (CRTS): Individual assigned responsibility for directing and coordinating aircraft recovery procedures and actions. CRTS is also known as Crash Recovery Team Leader (CRTL).
4 8FWI21-103 28 NOVEMBER 2012 3.7. Crash Recovery Team Member (CRTM): Individual tasked to perform aircraft recovery duties. 3.8. The US Air Force F-16C/D aircraft is the primary Mission Design Series (MDS) assigned to 8 FW. 4. Responsibilities 4.1. 8th Maintenance Group Commander (8 MXG/CC) is responsible for the crash recovery program. The 8th Maintenance Squadron, Maintenance Flight, Crash Recovery/Transient Alert Section (8 MXS/MXMTT), section chief or designated representative will assume the duties of CRTS. 4.2. The MXS/MXMTT will 4.2.1. Establish the 8 MXG CDDAR program and serve as OPR for the unit CDDAR instruction. 4.2.2. Develop, in conjunction with the 8th Maintenance Operations Squadron, Maintenance Training Flight (8 MOS/MXOT), course control documents and the course curriculum for crash recovery training. 4.2.3. Review support agreements and the base disaster response plan on an annual basis. Provide inputs/changes as required. 4.2.4. Ensure CDDAR procedures are coordinated with the 8 CES/CEF, 8 FW/SE, 8 CES/CEX/CEO/CEORHG, 8 SFS, 8 MDOS/SGOJ, 8 OSS/OSAM and on/off base agencies (as required). 4.2.5. Inform the 8th Maintenance Group Commander (8 MXG/CC) in writing of equipment shortages/un-serviceability that precludes effective CDDAR support/response. (See Attachment 4) 4.2.6. Ensure sufficient personnel are trained to support CDDAR operations. This includes: 4.2.6.1. Basic equipment operation (e.g., light carts, generators, etc.). 4.2.6.2. Familiarization training on any unique characteristics/hazards/materials for assigned aircraft (i.e., F-16 EPU, hydrazine, aircraft composite material etc.). Ensure training is documented. 4.2.6.3. Proper use of Personnel Protection Equipment (PPE) as determined by technical data and the base Bioenvironmental Engineer (BEE). Crash recovery PPE gear listing and training qualification/information will be maintained at the 8 MXS/MXMTT. 4.2.6.4. Special qualifications for personnel. Ensure individual team member qualifications for specific equipment operations (i.e., lift bags, recovery one truck, tow vehicle, 30 ft. trailer, crane etc.) are identified and documented. 4.2.6.5. Serviceable tools and support equipment for recovery operations (i.e., bags, slings, manifolds, tow bars, dunnage/shoring, etc.) are available. Maintain a list of all CDDAR tools and equipment. (See Attachment 4).
8FWI21-103 28 NOVEMBER 2012 5 4.2.6.6. Inspect tools and support equipment for recovery operations (i.e., bags, slings, manifolds, tow bars, dunnage/shoring, etc.) for proper paperwork and documentation (i.e., AFTO Form 244 s and AFTO 95 s, load test certification). 4.2.7. Normal Responses: Assign an F-16 qualified Crash Recovery Team (CRT) consisting of at least three members including a Team Leader qualified to the seven-skill level (minimum). The second CRT member will be assigned to the CRT team leader and the third member will be a qualified aircraft tow vehicle operator and CRT member. The aircrew member will act as a brake rider if mission/time constraints dictate. 4.2.8. Major Responses: An aircraft crash, runway/taxiway departure or any event requiring an aircraft lift, a qualified Crash Recovery Team Chief will assume responsibility once cleared into scene from SFO or IC. Absolutely no recovery operations will commence until the Safety Investigative Board President or designated official has clarified his/her expectations. The assigned CRT members will consist of at least six members with a Team Leader qualified to the seven skill-level (minimum). The remaining five team members will be qualified in all aspects of Crash Damaged, Disabled, and Recovery (CDDAR) operations. 4.2.9. Ensure a CRT is available during all scheduled flying hours and a standby crew is designated for all non-scheduled flying hours. A list of standby CRT members will be published weekly and furnished to the 8 MXG Maintenance Operations Center (MOC), through 8 MXS supervision, on the standby duty roster. Refer to 8 MXS weekend duty standby listing. 4.2.10. Ensure the following equipment is centrally located and available for emergency dispatch 24 hours a day. (Refer to Attachment 5) 4.2.10.1. Primary response vehicle, designated Recovery 1, will be a 6-passenger, 1- ton, 4X4 pickup with heavy duty pintle-hook utility body (or equivalent, i.e. bed mounted tool boxes) for storage and security of all tools and immediate normal response crash equipment. This vehicle will be equipped with off road capable tires, emergency lights, siren, LMR radio (capable of monitoring the Fire, Ramp and Tower radio frequencies), technical orders, tools and safety equipment to perform immediate normal response operations. 4.2.10.2. Secondary response vehicle, designated Recovery 4, will be a 6-passenger, 1-ton, 4X4 pickup with heavy duty pintle-hook, utility body (or equivalent, i.e. bed mounted tool boxes) for storage and security of all tools and immediate response crash equipment. This vehicle will be equipped with off road capable tires, emergency lights, siren, LMR radio (capable of monitoring the Fire, Ramp and Tower radio frequencies), technical orders, tools and safety equipment to perform immediate normal response operations. 4.2.10.3. 10-ton Semi truck, designated Recovery 3 and a 30 ft enclosed trailer (for storage and transportation of major response recovery equipment). 4.2.10.4. Aircraft tow vehicle, MB-2 or equivalent, designated Recovery 2. Tow vehicle will be equipped with emergency lights and an LMR radio that is capable of monitoring the Fire, Ramp and Tower radio frequencies.
6 8FWI21-103 28 NOVEMBER 2012 4.2.10.5. Aircraft tow bar (universal). Tow bar must be capable of towing the primary MDS assigned to Kunsan AB. Scheduled maintenance and periodic inspections will be performed by 8 MXS AGE Flight. 4.2.10.6. Two disabled wheel dollies. Scheduled maintenance and periodic inspections will be performed by 8 MXS AGE Flight. 4.2.10.7. Applicable 60-ton Crane. 60-ton crane will be owned and operated by 8 MXS personnel. Scheduled maintenance and/or periodic inspections will be performed by or contracted through 8th Logistics Readiness Squadron, Vehicle Management Flight (8 LRS/LGRV). 4.2.10.7.1. In the event the 8 MXS crane is rendered disabled/ unserviceable, coordination through 8 CE Heavy Repair Shop (8 CES/CEOH) will be used to procure an alternate crane. 4.2.10.7.2. In the event an alternate crane cannot be procured through 8 CE Heavy Repair Shop, an off base contractor will be employed. An off the shelf style contract will be used to facilitate the 8 MXS crane requirement. The contract will specify: 4.2.10.7.2.1. A 25 ton, 50 ton, and 100 ton capacity crane will always be available. The CRTC will decide which crane is appropriate for the situation. 4.2.10.7.2.2. The crane operator will remain with the crane for the duration of the recovery operation, or until released by the CRTS. 4.2.10.7.2.3. It is the crane owner/operators responsibility to ensure the crane remains fueled and serviceable during the operation. 4.2.10.7.2.4. The crane operator is required to comply with all directions given by the CRTS, unless safety is compromised. The owner/operator will be responsible for any injuries/damage caused by unsafe or undirected actions made by the provided operator. 4.2.10.7.2.5. The crane owner/operator will deliver the crane to requested location as soon as safely possible. 4.2.10.8. F-16 sling, bellybands, snatch cables, chains, etc. 4.2.10.9. PPE approved by BEE required to perform recovery of aircraft containing composites, to include, but not limited to, respirators, protective suits, boots, gloves, etc. 4.2.11. Conduct/participate in quarterly training exercises. Coordinate with the 8FW/XPI and 8 OSS/OSAM at least 48 hours prior to exercises for all potential crash scenarios. 4.2.12. Coordinate with unit QA weight and balance manager when weight and Center of Gravity (CG) conditions are unknown. 4.3. The CRT responds to all In-Flight Emergencies (IFE) and Ground Emergencies (GE) and is responsible for removal of disabled, damaged and/or crashed aircraft from the active runway, taxiways or other areas on or off base. The CRT also has responsibility for
8FWI21-103 28 NOVEMBER 2012 7 composite material mishap containment and cleanup IAW AFI 21-101 COMBAT AIR FORCE SUP. 4.4. The SFO is in command of IFEs and GEs until the danger of fire or explosion has been eliminated or a trained and qualified representative assumes command as the IC. 4.5. Aircraft removal/recovery will not commence until the IC or SFO has released the aircraft to the CRT. 4.6. The 8 MXS production superintendent will coordinate with the MOC for all CRTS support requests from on/off base agencies IAW AFI 21-101, para 14.10.2.7.2. 4.7. The 8 MXS Accessories Flight Fuels Section will provide a Hydrazine Response Team (HRT) for all hydrazine related aircraft emergencies. The HRT is responsible for detection, neutralization and clean up of hydrazine leaks/spills IAW AFI 21-101_ COMBAT AIR FORCE SUP. 4.8. The 8 CES/CEF, in conjunction with the 8 SFS, is responsible for establishing a 300- foot cordon and notifying the EOC who will in-turn notify other agencies to clear the area. The IC or HRT may expand the cordon size as the situation warrants IAW AFI 21-101_COMBAT AIR FORCE SUP. 4.8.1. The 8 SFS has no authority off base to establish the cordon or Entry Control Point (ECP). 4.9. The 8 MDOS/SGOJ will monitor the area for nuisance hazards, hazardous vapors, etc., upon request by the IC, SFO or CRTS. 4.10. The 8 MXS Munitions Flight (8 MXS/MXMW) will provide a driver and 40-foot flat bed trailer or MHU-110 munitions trailer as needed for removal of munitions/explosives. 4.11. 8 SFS, when directed by the IC or EOC, will establish and maintain a cordon and entry/exit control point until released by the IC or EOC. 4.11.1. The 8 SFS has no authority off base to establish the cordon or ECP 4.12. The 8 MXS AGE Flight (8 MXS/MXMG) will provide ground equipment at the request of IC, and/or CRTS. All equipment must be readily available for use during CDDAR operations. (See Attachment 2) 4.13. The 8 LRS Vehicle Operations Flight (8 LRS/LGRDDO) will provide qualified drivers and special purpose vehicles at the request of IC, EOC and/or CRTS. All vehicles and drivers must be readily available for use during CDDAR operations. (See Attachment 3) 4.14. MOC will maintain a current MAJCOM/owning organization telephone roster of points of contact for aircraft transiting Kunsan AB. This roster will be used to notify the appropriate organization in the event of a mishap. MOC will be the focal point to relay information between the CRTS and the MAJCOM/owning organization. 5. Crash Recovery Response Procedures. 5.1. Normal Response: 5.1.1. The CRT will consist of a Crash Recovery Team Leader (CRTL) and two recovery members. The CRTL will respond with one CRTM in the primary crash recovery
8 8FWI21-103 28 NOVEMBER 2012 vehicle. The second CRTM will standby with an aircraft tow vehicle for further guidance from the CRTL. The CRTL will establish and maintain radio contact with the IC on the Fire net. 5.1.2. If upon landing the aircraft stops on the active runway, the IC will normally determine if a fire or explosive hazard exists. Once the fire or explosive hazard is eliminated, the IC will normally clear the CRTL to begin recovery operations. 5.1.3. The CRT will establish interphone/hand signal communication with the aircraft commander and if no further assistance is required, the CRT will clear the aircraft to taxi to End of Runway (EOR) and be de-armed by the EOR crew. The IC will normally terminate the In-Flight Emergency. 5.1.4. If further assistance is required, the CRTL will supervise normal engine shutdown procedures on the runway. The CRT will, with the pilot as brake rider, tow the aircraft to an open parking location at either North or South EOR. The EOR crew will respond to de-arm the aircraft. The CRTL will then contact Dragon Super. Dragon Super will coordinate with the respective squadron and based on mission requirements, either tows the aircraft to its squadron location or request the squadron send a tow crew to retrieve the aircraft from EOR. Once the aircraft has cleared the runway the IC will normally terminate the IFE. 5.2. Major Response: 5.2.1. The CRT will consist of a recovery supervisor and five recovery members. The CRTC will respond with one CRTM in the primary crash recovery vehicle. A second CRTM will standby with an aircraft tow vehicle for further guidance from the CRTS while the remaining CRTMs will respond as necessary. 5.2.2. The CRTC will, if required, notify the 8 MXS Munitions Flight, Munitions Control (8 MXS/MXMWSA) to dispatch a driver and MHU-110 trailer to Hangar 2825. The CRTS will establish and maintain radio contact with the SFO or IC on the Fire net. 5.2.3. Aircraft Departs Runway/Taxiway/Crash: 5.2.3.1. Once cleared by the SFO or IC, the HRT will check for hydrazine leaks or spills. If leaks/spills are discovered, the HRT will clear/safe the area IAW LCL- 8MXG-009, F-16 Hydrazine Leak Detection, Activated EPU Checks. 5.2.3.2. Once cleared by the HRT supervisor, the CRT will inspect the aircraft for damage to items containing composite materials. The CRT will secure all loose composite fibers IAW T.O. 00-105E-9, Aircraft Emergency Rescue Information. 5.2.3.3. The CRT will safe the aircraft for maintenance. 5.2.3.4. The CRTS will monitor the safing and/or removal of munitions by the applicable AMU. 5.2.3.5. The CRT will recover the aircraft IAW applicable safety standards, technical orders and instructions. 5.2.3.6. The CRT will transport the aircraft to a facility designated by the IC or 8 MXG/CC.
8FWI21-103 28 NOVEMBER 2012 9 5.3. Transient Aircraft: 5.3.1. Transient Alert (TA) will assist CRT with all transient aircraft emergencies and will supplement CRT upon request of CRTS or IC. Refer to T.O. 00-105E-9 for specific US Military and Civil aircraft hazards. 5.3.2. Should a transient fighter aircraft become damaged, disabled, or crashed, 8 FW Command Post or MOC will notify the appropriate MAJCOM/unit for further handling instructions. If the owning unit is on Temporary Duty (TDY) at Kunsan AB, the MOC will notify the TDY unit and request an aircraft technician and specialized equipment be dispatched to the scene. The dispatched technician will report to the IC or CRTS. 5.3.3. Should a wide-bodied aircraft become damaged, disabled, or crashes, the 8 FW Command Post or MOC will notify the appropriate MAJCOM/unit for further handling instructions. Further actions will be accomplished IAW pre-established MAJCOM agreements, or owning agency guidance. 5.3.4. General crash recovery procedures may be used to facilitate the safe recovery and removal of the aircraft; however, prior to any recovery/removal actions, MOC will contact the owning organization for technical support and relay acquired information to the CRTC. 5.3.5. The Patriot Express (PE) is considered a frequent visitor and will be handled as followed if disabled on the runway: owning agency will provide a qualified brake rider and tow supervisor, CRT will provide a tow vehicle, driver, and tow bar (if available). If unable to be towed from runway, owning agency will provide a team and equipment required to removed aircraft from runway. CRT will assist as determined necessary. 5.4. Tenant Agencies, i. e. Republic of Korea Air Force (ROKAF), are responsible for CDDAR support for their assigned aircraft. The 8 MXS CRT will respond and render assistance as requested/available. 5.4.1. Gunsan Civilian Airport frequent aircraft (737 s), will be handled as followed if disabled on runway: owning agency will provide a qualified brake rider, tow supervisor and appropriate tow bar. CRT will provide a tow vehicle and driver. 6. On/Off-Base Recovery Procedures. The wing commander through disaster response force, i.e., Wing Command Post (8 FW/CP), unit control centers, EOC and any specialized teams, coordinates on/off-base recovery actions. Refer to 8 FW CEMP 10-2, and 8 FW Mishap Response Plan 91-204 for agency/team responsibilities. 6.1. Runway closure and recovery priorities 6.1.1. As a minimum, a disabled aircraft on the runway or taxiway will be treated as a Ground Emergency (GE). Tower personnel and/or Supervisor of Flying will initiate GE procedures. 6.1.2. In the event that a crashed, damaged, or disabled aircraft is on the runway the 8 FW/CC or designated representative will determine the degree of urgency required to clear the runway. If immediate removal priority is given, the CRTC has the option of using heavy equipment from 8 CES after coordination with Airfield Management. CRTC will direct the operation and the CRT will assist as necessary to push, pull or lift the aircraft from the runway as the situation warrants.
10 8FWI21-103 28 NOVEMBER 2012 6.2. In the event of an off base incident that requires off-road capabilities in order to reach the scene, the CRTC will provide transportation to the Armament Flight response team when they are required to safe associated weapons systems. 7. Additional Training and Certification Requirements for CRT Personnel. 7.1. All CRTS will possess a valid AF Form 2293, US Air Force Motor Vehicle Operator Identification Card, and AF Form 483, Certificate of Competency, for flightline driving with the runway access stamp. 7.2. All CRTM will possess a valid AF Form 2293, and a valid AF Form 483, for airfield driving with a runway access endorsement stamp for Kunsan AB Controlled Movement Area (CMA). 7.3. All CRTM will be provided initial and recurring crash recovery training. Training will be updated in IMDS IAW AFI 21-101_COMBAT AIR FORCE SUP, Chapter 14. 7.4. All CRTM are specifically trained to recover the F-16C/CG primary assigned aircraft. 7.5. All crane operators will receive initial training and be re-qualified on an annual basis IAW AFOSHSTD 91-46, Materials Handling and Storage Equipment. 7.6. Perform recovery exercises at least annually IAW AFI 21-101_COMBAT AIR FORCE SUP, Chapter 14. 7.7. All CRTM will, as a minimum, receive familiarization training on primary assigned aircraft. 7.8. All CRTM will, as a minimum, receive aircraft familiarization training on any transient aircraft operating flying missions at Kunsan AB for an extended length of time, (i.e., 3 or more months). 7.8.1. Aircraft Familiarization Training will consist of (at a minimum): 7.8.1.1. Specific aircraft -21 safety equipment locations and installation required to safe the aircraft in an emergency. 7.8.1.2. Aircraft Danger Areas: Engine inlet and exhaust(s) zones, flight control surface hazards, auxiliary power supply/unit exhaust port(s), and any other hazards CRT may encounter during an emergency response/recovery. 7.8.1.3. Training will be conducted by the transient unit, specific aircraft commander, flight crew and/or qualified aircraft crew chief(s). 7.8.1.4. The 8 MXG/CC has determined that the 8 MXS CRT will only equip and train for recovery of 8th Fighter Wing primary assigned aircraft.
8FWI21-103 28 NOVEMBER 2012 11 8. Supplemental Procedures. 8.1. For emergency aircraft cable/barrier engagement procedures, see LCL-8MXG-003. 8.2. During wing deployments/contingencies to operational locations, this instruction will be implemented unless other directives are already in effect at the deployed location. JOHN W. PEARSE, Colonel, USAF Commander
12 8FWI21-103 28 NOVEMBER 2012 References Attachment 1 GLOSSARY OF REFERENCES AND SUPPORTING INFORMATION AFPD 21-1, Air and Space Maintenance, 25 February 2003 AFI 21-101_COMBAT AIR FORCE SUP, Aircraft and Equipment Maintenance Management, 24 April 2007 AFI 10-2501, United States Air Force Emergency Management (EM) Planning and Operations, 24 January 2007 IC 2, 6 April 2009 AFI10-252, Air Force Incident Management System (AFIMS) Standards and Procedures, 9 August 2012 AFMAN 33-363, Management of Records, 1 March 2008 AFOSHSTD 91-46, Materials Handling and Storage Equipment, 1 August 2002 DODI 6055.6, DOD Fire and Emergency Services Program, 16 September 2010 DODM 6055.6, DOD Fire and Emergency Services Certification Program, 23 February 2006 T.O. 00-105E-9, Aircraft Emergency Rescue Information, 1 February 2006 8FWI 21-103, Crash, Damaged or Disabled Aircraft Recovery Plan, 6 Apr 2010 8FWI 91-202, Mishap Prevention Program, 26 August 2004 8FW CEMP 10-2, Comprehensive Emergency Management Plan, 19 May 2011 8FW OPLAN 31-1, 8FW Full Spectrum Threat Response, 11 March 2005 8FW OPLAN 91-202, Mishap Response Plan, 1 December 2007 8FW Mishap Response Plan 91-204, 1 December 2007 LCL-8MXG-003, Emergency Action Checklist, 5 December 2008 LCL-8FW-MS/TA-100, Crash Recovery Response Checklist, 1 July 2009 LCL-8MXG-009, F-16 Hydrazine Leak Detection, Activated EPU Checks, 4 January 2001, Change 1, 1 April 2009 FB52CX-MOAI-2016, Memorandum of Agreement, 24 February 2009 8 MOS/MTF Crash Recovery Lesson Plan, 19 March 2009 Adopted Forms AF Form 483, Certificate of Competency AF Form 847, Recommendation for Change of Publication AF Form 2293, US Motor Vehicle Operator Identification Card AFTO Form 244, Reporting Status of Aerospace Expeditionary Forces AFTO Form 95, Load Test Certification
8FWI21-103 28 NOVEMBER 2012 13 Abbreviations and Acronyms AFIMS Air Force Incident Management System AGE Aerospace Ground Equipment AMU Aircraft Maintenance Unit BEE Bioenvironmental Engineer CBRN Chemical, Biological, Radiological, Nuclear CDDAR Crash, Damaged or Disabled Aircraft Recovery CG Center of Gravity CMA Controlled Movement Area CRT Crash Recovery Team CRTC Crash Recovery Team Chief CRTL Crash Recovery Team Leader CRTM Crash Recovery Team Member CRTS Crash Recovery Team Supervisor DV-Distinguished Visitor ECP Entry Control Point EOC Emergency Operations Center EOR End of Runway EM Emergency Management EPU Emergency Power Unit FES Fire Emergency Service GE Ground Emergency HAZMAT Hazardous Material HRT Hydrazine Response Team IAW In Accordance With IC Incident Commander IFE In-Flight Emergency IMDS Integrated Maintenance Data System LCL Local Check List MAJCOM Major Command MDS Mission, Design, Series MOC Maintenance Operations Center OPLAN Operations Plan
14 8FWI21-103 28 NOVEMBER 2012 PE Patriot Express PPE Personnel Protection Equipment RDS Records Disposition Schedule ROKAF Republic of Korea Air Force SFO Senior Fire Official SME Subject Matter Experts TA Transient Alert TDY Temporary Duty T.O. Technical Order
8FWI21-103 28 NOVEMBER 2012 15 Attachment 2 GROUP LETTERHEAD STATIONARY SAMPLE MEMORANDUM Figure A2.1. Plan Aerospace Ground Equipment (AGE) Requirements MEMORANDUM FOR 8 MXG/CC Date: DDMMYYY FROM: 8 MXS/MXMTT SUBJECT: Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Plan Aerospace Ground Equipment (AGE) Requirements 1. The following listing identifies the minimum AGE required for CDDAR operations IAW AFI 21-101, Chapter 14, paragraph 14.10.3. Note: Each recovery operation is unique; therefore, AGE requirements are subject to change. Small bodied aircraft mishap (i.e., F-16, F-15, C-12). Type Equipment Quantity Special Requirements Light Carts 4 each Fully fueled MC-7 2 each One on standby Air Compressor (Low-pack) 1 each Fully fueled Portable Heater 3 each During extreme cold weather Wide-bodied aircraft mishap (i.e., C130, KC-10, Navy P-3) Type Equipment Quantity Special Requirements Light Carts 6 each Fully fueled MC-7 2 each One on standby Air Compressor (Low pressure) 2 each None Air Compressor (High pressure) 1 each None Portable Heater 4 each During extreme cold weather 2. The point of contact for this letter is the Transient Alert/Crash Recovery Section Chief at DSN 782- XXXX. FIRST MI. LAST, Rank, USAF 8 MXS Crash Recovery Team Chief
16 8FWI21-103 28 NOVEMBER 2012 Attachment 3 GROUP LETTERHEAD STATIONARY SAMPLE MEMORANDUM Figure A3.1. Special Purpose Vehicle Requirement MEMORANDUM FOR 8 MXG/CC Date: DDMMYYY FROM: 8 MXS/MXMTT SUBJECT: Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Special Purpose Vehicle Requirements 1. The following listing identifies types, quantities and special requirements for vehicles provided by 8th Logistic Readiness Squadron (8 LRS) required for CDDAR operations IAW AFI 2 1-101, Chapter 14, paragraph 14.10.3.. Each vehicle will be owned and operated by 8 LRS. Vehicle Type Quantity Special Requirements All Terrain Forklift 1 each none 40 ft. Flatbed Semi Trailer 1 each none Tractor for 40 ft. trailer 1 each none 2. The point of contact for this letter is the Transient Alert/Crash Recovery Section Chief at DSN 782- XXXX. FIRST MI. LAST, Rank, USAF 8 MXS Crash Recovery Team Chief
8FWI21-103 28 NOVEMBER 2012 17 Attachment 4 SAMPLE MEMORANDUM FOR EQUIPMENT SHORTAGE NOTIFICATION Figure A4.1. Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Equipment Shortfall MEMORANDUM FOR 8 MXG/CC FROM: 8 MXS/MXMTT Date: DDMMYYY SUBJECT: Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Equipment Shortfall 1. The following identifies shortage of primary equipment, which would hinder proper implementation of the wing CDDAR program. IAW AFI 21-101, Chapter 14, paragraph 14.10.5.5. Type Equipment: MB-2 Tow Vehicle. Discrepancy: Transmission Failure. Estimated Repair/Replacement Time: Unknown. Estimated Repair/Replacement Cost: Repair by/replacement part issuing from: 2. This letter supersedes all other letters same subject. Please direct any questions regarding subject to 8 MXS/MXMTT Transient Alert/Crash Recovery Section Chief at DSN 782-XXXX. ROUTING INITIALS: 8 M X S / M X M T : 8 MXS/MXM: 8 MXS/CC: //SIGNED// FIRST MI LAST, Rank, USAF 8 MXS Crash Recovery Team Chief
18 8FWI21-103 28 NOVEMBER 2012 Attachment 5 SAMPLE MEMORANDUM RESPONSE EQUIPMENT LISTING Figure A5.1. Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Plan Response Equipment Listing MEMORANDUM FOR 8 MXG/CC Date: DDMMYYY FROM: 8 MXS/MXMTT SUBJECT: Crashed, Damaged or Disabled Aircraft Recovery (CDDAR) Plan Response Equipment Listing 1. The following listing identifies primary crash recovery equipment required to support wing CDDAR responses. Each piece of equipment/tool has been strategically located within the 8 MXS complex and shall have 24-hour availability IAW AFI 21-101, Chapter 14, paragraph 14.10.3. 2. Primary crash recovery equipment will be located in the 30ft. crash trailer and consists of 160 items. Refer to Material Inventory Listing KUTARECV3 for individual equipment/tool listing. 3. Secondary/Quick response crash recovery equipment will be located in the recovery 1 (6 pack) vehicle. Refer to Material Inventory Listing KUTARECOV for individual equipment/tool listing. 4. This letter supersedes all other letters same subject. For individual equipment/tool status or any questions regarding this subject please contact 8 MXS Transient Alert/Crash Recovery Section at 782- XXXX. //SIGNED// FIRST MI LAST, Rank, USAF 8 MXS Crash Recovery Team Chief
8FWI21-103 28 NOVEMBER 2012 19 Attachment 6 SAMPLE MEMORANDUM VEHICLE REQUIREMENTS Figure A6.1. Vehicle Requirements for Crashed, Damaged or Disabled Aircraft Recovery Response MEMORANDUM FOR 8 MXG/CC Date: DDMMYYY FROM: 8 MXS/MXMTT SUBJECT: Vehicle Requirements for Crashed, Damaged or Disabled Aircraft Recovery Response 1. The following listing identifies primary and alternate recovery vehicles required for CDDAR response. Each vehicle has been strategically located within the 8 MXS complex and shall have 24-hour availability IAW AFI 21-101, Chapter 14, paragraph 14.10.3. Primary Vehicles Reg. Number Location Recovery 1 (6 pack) 03B01588 Building 2852 MB-2 (tow-vehicle) 02L00 122 Building 2852 60-ton Crane 85D00082 Building 2825 10-ton Tractor 01B00001 Building 2825 30 ft. Equipment Trailer 00B01 114 Building 2825 Alternate Vehicles Reg. Number Location TA-1 (4 pack) 03B0932 Building 2852 TA-2 (4 pack) 03B2615 Building 2852 U-30 (Tow Tractor) 87L201 Building 2814 2. For individual vehicle status please contact 8 MXS Transient Alert/Crash Recovery section at 782- XXXX. //SIGNED// FIRST MI LAST, Rank, USAF 8 MXS Crash Recovery Team Chief