* TM -3895-0-4P DEPARTMENT OF THE ARMY TECHNICAL MANUAL ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LISTS (INCLUDING DEPOT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS) FOR REEL UNITS RL-3, RL-3B, RL-3C, RL-3D, AND RL-3E (NSN 3895-00-5-6896) 4 August 978 Headquarters, Department of the Army, Washington, D.C. Current as of 8 February 978 REPORTING OF ERRORS You can help improve this manual by calling attention to errors and by recommending improvements and stating your reasons for the recommendations. Your letter or DA Form 08 (Recommended Changes to Publications and Blank Forms) should be mailed directly to Commander, US Army Communications and Electronics Materiel Readiness Command, ATTN: DRSEL- MA-Q Fort Monmouth, New Jersey 07703. A reply will be furnished directly to you Table of Contents Section I. Introduction...................................... Page Ills Figure II. Repair Parts List................................................................. 5 Group 00 Real Units RL-3, RL-3B, RL-3C, RL-3D, and RL-3E.......................... 5 Section III. Special Tools List (Not Applicable) IV. National Sttock Number Part Number Index.......................... 6 mbgaapraab lml--sm?, rsawgaatls7t
SECTION I INTRODUCTION. Scope This manual lists spares and repair parts; special tools; special test, measurement, and diagnostic equipment (TMDE), and other special support equipment required for performance of organizational and direct support maintenance of the RL-3, RL-3B, RL-3C, RL-3D, and RL-3E. It authorizes the requisitioning and issue of spares and repair parts as indicated by the source and maintenance codes.. General This Repair Parts and Special Tools List is divided into the following sections: a. Section II. Repair Parts List. A list of spares and repair parts authorized for use in the performance of maintenance. The list also includes parts which must be removed for replacement of the authorized parts. Parts lists are composed of functional groups in numeric sequence, with the parts in each group listed in figure and item number sequence. b. Section III. Special Tools List. Not applicable. c. Section IV. National Stock Number and Part Number Index. A list, in National item identification number (NUN) sequence, of all National stock numbers (NSN) appearing in the listings, followed by a list, in alphameric sequence, of all part numbers appearing in the listings. National stock numbers and part numbers are cross-referenced to each illustration figure and item number apeparance. 3. Explanation of Columns a. Illustration. This column is divided as follows: () Figure number. Indicates the figure number of the illustration on which the item is shown. () Item number. The number used to identify item called out in the illustration. b. S o u r c e, Maintenance, and Recoverability (SMR) Codes. () Source code. Source codes indicate the manner of acquiring support items for maintenance, repair, or overhaul of end items. Source codes are entered in the first and second positions of the Uniform SMR Code format as follows: Code Definition PA Item procured and stocked for anticipated or known usage. NOTE Cannibalization or salvage may be used as a source of supply for any items source coded above except those coded XA and aircraft support items as restricted by AR 700-4. () Maintenance code. Maintenance codes are assigned to indicate the levels of maintenance authorized to USE and REPAIR support items. The maintenance codes are entered in the third and fourth positions of the Uniform SMR Code format as follows: (a) The maintenance code entered in the third position will indicate the lowest maintenance level authorized to remove, replace, and use the support item. The maintenance code entered in the third position will indicate one of the following levels of maintenance: Code Application/Explanation O Support item is removed, replaced, used at the organizational level. F-Support. item is removed, replaced, used at the direct support level. (b) The maintenance code entered in the fourth position indicates whether the item is to be repaired and identifies the lowest maintenance level with the capability to perform complete repair (i.e., all authorized maintenance functions). This position will contain the following maintenance code: Code Application/Ezplanation Z-Nonreparable. No repair is authorized. (3) Recoverability code. Recoverability codes are assigned to support items to indicate the disposition action on unserviceable items. The recoverability code is entered in the fifth position of the Uniform SMR Code format as follows: Recoverability codes Definition Z-Nonreparable item. When unserviceable, condemn and dispose at the level indicated in position 3. c. National Stock Number. Indicates the National stock number assigned to the item and will be used for requisitioning purposes. d. Part Number. Indicates the primary number used by the manufacturer (individual, company, firm, corporation, or Government activity), which controls the design and characteristics of the ltem by means of its engineering drawings, specifications,
standards, and inspection requirements to identify b. The following publication pertains to the RL-3, an item or range of items. RL-3B, RL-3C, RL-3D, and RL-3E and its components: NOTE When a stock-numbered item is requisi- TM -36, Reel Units RL-3, RL-3B, RL-3C, tioned, the repair part received may have RL-3D, and RL-3E a different part number than the part being replaced. 5. How to Locate Repair Parts a. When National stock number or part number e. Federal Supply Code for Manufacturer is unknown. (FSCM). The FSCM is a 5-digit numeric code listed in SB 708-4 which is used to identify the manu- () First. Using the table of contents, deterfacturer, distributor, or Government agency, etc. f. Description. Indicates the Federal item name and, if required, a minimum description to identify the item. mine the functional group within which the item belongs. This is necessary since illustrations are prepared for functional groups and listings are divided into the same groups. g. Unit of Measure (U/M). Indicates the standard () Second. Find the illustration covering the of the basic quantity of the listed item as used functional group to which the item belongs. in performing the actual maintenance function. This measure is expressed by a two-character alphabetical abbreviation (e.g., ea, in, pr, etc). When the unit of measure differs from the unit of issue, the (3) Third. Identify the item on the illustration and note the illustration figure and item number of the item. lowest unit of issue that will satisfy the required (4) Fourth. Using the Repair Parts Listing, find units of measure will be requisitioned. the figure and item number noted on the illustration. h. Quantity Incorporated in Unit. Indicates the quantity of the item used in the breakout shown on the illustration figure, which is prepared for a b. When National stock number or part number functional group, subfunctional group, or an assem- is known. bly. () First. Using the Index of National Stock 4. Special Information Numbers and Part Numbers, find the pertinent Naa. Usable on codes are shown in the description tional stock number or part number. This index is in NIIN sequence followed by a list of part numcolumn. Uncoded items are applicable to all models. hers in alphameric sequence, cross-referenced to Identification of the usable on codes used in this the illustration figure number and item number. publication are: used on () Second. After finding the figure and item RL3 number, locate the figure and item number in the RL-3B repair parts list. 5C5 RL-3C 4PP RL-3D 6. Abbreviations 4T5 RL-3E Not applicable. (Next printed page is 4) 3
TM -3895-0-4P Figure. Reel Units M-3, RL-3B, RL-3C, RL-3D, and RL-3E. 4
TM -3895-0-4P 0) LusTRAmoo Gi- P3G ii- 3 SM () 5MR XOE (3) MnoNAL STOCM NUMSSR SECTION II. REPAIR PARTS LIST (4) PART NUMSER (5) MN (6) oesulpma4 USABLS ON coos (7) INIT OP UcAs (0) WY INC IN LINT GROUP 00 Rm UrTz RL-3, RL-ns, Rk3c, RL-3D, ASD L-33E kozz i65-co-b98-73 T9A,AW map 4 3 Wzz kozz )95-W-3D-58.95 395-Do-69+87 CDllb8 Claa 0058 XL W OllIT A A 4 Uz3 )95-DD-E T-037 cd83 0C43 RACE, LzG 4PP, 5C3, 5CJ, 5C5 A 5 WZ 395-GO-X7+369 CbA QD58 RAK A 6 Uzz )95-DD-r7-G976 CD379 LUGn A b 7 Nzz 36G-DD-33-3@0 CDl5T6DIm6 GI%3 PRG PA 8 Uzz 995-00-633-5799 CD5?6-3 ATalm, LAlwl u 9 mz ug-w-45-hl lun599g m63 I&K. KARIW Z4 0 Uzz )95-D&5e8-b7% CD5763TU4? AP, SE4RIRI ZA U Uzz k5-00-35-8 CDl579~l ISK, SRAKB u 8 3 Wzz kpz?5d-dd-k7-05 )95-00-35-333 CD575 cdl5t9trm0 tlc63 QD63 RACE AzmsLY IISK, RAKE ht5 4 m 0 5
TM -3895-0-4P SECTION IV. NATIONAL STOCK NUMBER AND PART NUMBER INDEX FIGURE so. ~ SlOCK?iUMSER FIGURE ITEM 3895-00-7-0969 3895-00-7-0976 3895-00-7-037 395O-OO-7-O5 5360-00-33-3780 830-00-h5-hl 3895-GO-3ol-5885 3895-00-35-8 f? 3895-00-35-83 4 8465-00-498-73 3895-00-588-4796 38s$5-00-69-9487 ; 3895-00-633-5799 3 0 i PART SUMSES FSCM FIG. ITEM Ho. FIG. PART mm FSCM lio. ITF3 DLSMS5W0 GCOA GC4A scdn48 SCD575 SCD576-3 SCD576DITEM6 m%; 80058 8 8 8 8 9 35 87 SCD576TP?4 8 scdl579tmllo 8 scdl579mll 8 SCD379 8 SCD83 8 ST9A,AV 8 0 3 6b 6
By Order of the Secretary of the Army: Official: BERNARD W. ROGERS General, United States Army Chief of Staff J. C. PENNINGTON Brigadier General, United States Army The Adjutant General
Active Army: USAINSCOM () COE () TSG () USAARENBD () USAIB () DARCOM () TECOM () TRADOC () OS Maj Comd (4) USARJ () MDW () Armies () corps () HISA (Ft Monmouth) (3) Fort Gillem (0) Fort Gordon (0) Fort Huachuca (0) Fort Carson (5) Ft Richardson (CERCOM Ofc) () Svc Colleges () USASIGS (5) USAICS (3) USATSCH () USAADS () USAFAS () USAARMS () USAIS () USAES () USAOC&S () USAMPS () AD () except SAAD (30) LBAD (4) TOAD (4) SHAD (3) USA Dep () Sig Sec USA Dep () USAECFB () MAAG () USARMIS () USAERDAA () USAERDAW () USACRTC () USATC FA () Units org under fol TOE: ( ea. UNOINDC) -5-6 -7-8 -9-5 -6-7 -37-33 -36-45 -46-47 -35-66 -87-5 -97-98 -6-7 - -7-37 -47-05 -07-5 -7-8 -5-7 -8-37 -30-303 -37-57 -500 (AA-AC) 9-07 () 9-60 () ARNG: State AC (3); Units-Same as Active Army except allowance! is one () copy per unit. USAR: None. For explanation of abbreviations ussd, see AR 30-50. *U.S. GOVERNMENT PSINllNG OFFICE: 993-34-4/S0S7S PIN: 0546-000
This fine document... Was brought to you by me: Liberated Manuals -- free army and government manuals Why do I do it? I am tired of sleazy CD-ROM sellers, who take publicly available information, slap watermarks and other junk on it, and sell it. Those masters of search engine manipulation make sure that their sites that sell free information, come up first in search engines. They did not create it... They did not even scan it... Why should they get your money? Why are not letting you give those free manuals to your friends? I am setting this document FREE. This document was made by the US Government and is NOT protected by Copyright. Feel free to share, republish, sell and so on. I am not asking you for donations, fees or handouts. If you can, please provide a link to liberatedmanuals.com, so that free manuals come up first in search engines: <A HREF=http://www.liberatedmanuals.com/>Free Military and Government Manuals</A> Sincerely Igor Chudov http://igor.chudov.com/ Chicago Machinery Movers